|Topic Review (Newest First)|
|06-16-2008 12:11 PM|
|Vasco||The Volvo shifter is the only good thing Volvo ever made (based on my experience with a Volvo 2003, world's worst engine) but it needs to be lubricated once in a while. It is easy to take the shifter apart and grease it. Try this first.|
|06-16-2008 12:03 PM|
Originally Posted by adam View Post
As a reference, I did this on my Catalina 30 in about 3 hours. I had an Edson pedestal, and getting the cables removed and attached there was a bit of a pain. I had to remove my autopilot to do so. I'm pretty mechanically inclined, and had never done this before.
|06-16-2008 11:40 AM|
thanks for the replys,
this is on a benetaeu 411, i was on another B 393 where the throttle cable broke.
this one seems like there is a little slack in the cable , and it not getting a full throw in the shift part.
i looked at both ends for a play adjustment, but it seems the only way is to take off one end and adjust it that way,,,
How hard is it to install new cables?
|06-16-2008 10:01 AM|
Originally Posted by trantor12020 View Post
Replace both your throttle and shifter cables at the same time. It's not much more additional work to do 'em both.
Before you pull the old cables, count and record the number of threads exposed at each end. This will make it easy for you duplicate the setup of the new cables and save you lots of monkeying around.
Also, inspect the old cables carefully. You're likely to find a place where the outer casing was rubbed away, which is probably the root cause of you problem. You should correct that.
The cables cost somewhere around $30 - $50. Beats pulling the transmission!
|06-16-2008 08:56 AM|
|trantor12020||adam, perhaps you could disconnect the shifter cables from the lever and check whether the stiffness is at the lever gear mechanism or the cable/s.|
|06-15-2008 11:37 PM|
yes , i think this shifter ( volvo penta) is the standard used in this beneteau sailboat. it is single throw , shift and throttle, it's just not in gear
when the shifter says it should be,,
|06-15-2008 08:31 PM|
I don't understand the mix of the Yanmar and the Volvo Penta items.
Is the shifter stiff, or sloppy?
|06-15-2008 07:48 PM|
Stiff Shifter Yanmar 4JH2E volvo penta shifter/throttle
our shifter is really getting tough, it's hard to find neutral, feels very sloppy,
Trying to find gears can be done, but,,, is there any maintance or adjustments to do?