|Topic Review (Newest First)|
|02-22-2009 11:24 AM|
You'd be much better off using all eight T105's for a house bank and setting up a small starting battery. Then connect all the charging sources to the big house bank and use an echo charger to charge the starting bank. The eight-bank house setup will actually give you more run time than it did when it was two four-battery house banks, since the Peukert factor goes down.
|02-22-2009 10:56 AM|
Since the thread's revived anyway...
Just curious here fellas, but why not keep the deep cycles split into two banks for redundancy and use a separate start battery without wiring it to the onboard charger at all ?
Either a two- or a three-channel isolator in the alternator's output will take care of separating the start and house batteries, and I would expect that motoring out of the marina will be more than enough to replenish the start battery. For the start battery to self-discharge would take quite a while.
It would be easy enough to wire a parallel relay between the house banks' battery switch and the starter just in case the start battery is flat (did I mention I like redundancy? ;^)
|02-22-2009 10:31 AM|
I am in the middle of installing my echo-charger and starting battery and I have a couple of questions.
1) The alternator has a + that I will connect to the main switch and then to the house batteries, but it also (according to the wiring diagram) has some wires (labeled R & L) that connect into the Starter Switch and I think a Charging light. What do I do with these and are they of any concern?
2) The easiest conversion for me is to keep my two house banks and then add the starting battery. Can I connect the echo-charger house battery connection to the positives of each house bank. I like the two house bank setup because I can continue to use my link 2000 to monitor each bank and charge them independently with the battery charger, alternator and wind generator if necessary.
An additional change from my initial post is that I have decided to replace all 8 6v Trojan T-105s with 2 AGM Group 4D (1 per bank) and will be using a Group 24 AGM Starting Battery. I have a Yanmar 4JHE engine.
|02-11-2009 07:30 PM|
|chucklesR||Optima brand spiral cell AGM's are able to handle the higher voltages typically associated with 'wet cell' batteries. I use nothing but them for both house and starter but if you are looking to mix that's a good choice if you are worried about over voltage on the starter. IIRC it can handle up to 14.8v without burnoff/damage. I charge at 14.3v and have had no problems at all in three years of use.|
|02-11-2009 01:56 PM|
|RAGTIMEDON||I'd be inclined to combine all the Trojan wet cells into the house bank and buy a 27 wetcell for starting, connected thru the Echocharger. Two reasons for this choice. If you use an AGM, as was stated before the optimum charging voltage is lower than that of thr Trojan wet cells, so the echocharger will possibly cook the start battery. The wet cell will give you the most bang for the buck, but have a shorter life expectancy than a properly charged AGM. Therefore you will not feel so bad about scrapping it at the time the trojans need replacement, and you want to go with all batteries of the same type and age. The major disadvantages to wet cells are: you can spill acid if the boat is knocked down, and you have to check regularly to see that there is water in all cells. Since you have this problem with the trojans anyway, why worry?|
|02-11-2009 01:39 PM|
Cam was just pulling your chain a bit, and mine :-)
Boring, yes, but the way to go for sure!
Let us know how you like it after a few months.
|02-11-2009 12:46 PM|
I am charging the house bank off of Charger, Alternator and Wind Generator. I know that the Charger and Alternator have 3 stage charging. The wind generator has a regulator, but I think that it just a simple one.
The charger and alternator have been tuned for the specifically for the Trojan lead acid batteries that I have. The only source of charge on the echo-charger will be a spill over from the house bank.
|02-11-2009 12:42 PM|
|camaraderie||Kinda...I think your instincts on this are fine and Trayfors as usual provides the correct but boring solution! C'mon Bill...we need a NEW solution...change and hope ya know!!|
|02-11-2009 10:35 AM|
I'd combine all the T-105's into a single house bank, and connect ALL onboard charging sources to charge that bank.
Then, add a Group 31 starting battery -- flooded or AGM -- and an EchoCharge device to maintain that starting battery.
Unlike deep-cycle batteries, starting batteries are designed with thin plates to deliver a lot of amps quickly, for a relatively short time. This will make your engine very happy. And the EchoCharge will make the starting battery very happy.
|02-11-2009 10:23 AM|
Originally Posted by KindOfBlue View Post
Are you talking about charging from a battery charger, or simply off an alternator, or both? Does the alternator have a "smart" regulator that is adjustable for battery types, or is it a simple stock alternator with a pre-set internal regulator? Do you know what voltage that regulator is set for?
Answers to those questions would be helpful. But my gut is that an AGM starting battery should be okay if it's getting the juice from an echo-charger. But there are some sealed lead-acid starting batteries that might work just as well.
|This thread has more than 10 replies. Click here to review the whole thread.|